109627_0910 5-1
STORAGE
When storing the unit at the end of the operating season, the
following steps should be taken to ensure readiness for the
next season.
1. Remove all grass, dirt, and trash from tractor and
mower. Clean tractor and mower and touch up all
scrapes with Hustler spray paint.
IMPORTANT:
Wash the machine with a mild detergent and
water. Do not pressure wash the machine. Avoid excessive use of
water
2. Install new air filter per Engine Owner’s Manual.
3. Check thoroughly for any worn or damaged parts that
need replacing and order them from your dealer.
4. If the tractor does not have a deck mounted, raise the
lift arms hydraulically to their fully raised position so
that the lift cylinder is fully retracted. This will protect
the cylinder rod surfaces from corrosion.
5. Lubricate the unit. Drain and refill the transmission,
hydraulic system and front axle with new oil.
6. Block tractor up so weight is off tires.
7. Do not deflate tires.
8. Perform separate engine preparation as listed below.
9. Store tractor in a clean, dry place.
10. Remove the battery from machine
a. Clean battery
b. Check the electrolyte level
c. Charge the battery, if necessary
d. Store battery in a cool, dry place (do not expose to
freezing temperatures)
e. Always keep the battery fully charged. (Especially
important to prevent battery damage when the
temperature is below 32
o
F (0
o
C).)
Preparation of engine for storage
When engine is to be unused for long periods, proceed as
follows:
1. Run engine for a minimum of 15 minutes.
2. Drain oil from crankcase while engine is still warm.
3. Refill with fresh oil of proper viscosity.
4. Special precautions should be taken to protect the fuel
injection pump and injector nozzle against corrosion
and gumming.
5. Flush the fuel system with a special oil, a quantity of
which will remain in the system when the engine is
shutdown. Special diesel fuel system flushing oils are
available from most oil companies. If this oil is not
available, mix 0.5 qts.(0.5 liters) of SAE 10 non-
detergent engine oil with 2.64 gal. (10 liters) of No. 2
diesel fuel. Drain the fuel tank and pour 1.85 gal. (7
liters) of the special flushing oil (or lubricating
mixture) into the fuel tank. Run the engine for 10
minutes to ensure complete distribution of the special
oil through the injection pump and fuel injectors. There
is no need to remove the injector nozzles.
6. Fill the fuel tank with No. 1 diesel fuel. IMPORTANT:
Do not use No. 2 diesel fuel, for winter storage,
because of wax separation and setting at low
temperature.
7. Open the drain valve on the radiator. Flush the system,
close the drain valve and fill with a 50/50 solution of
permanent antifreeze and clear water..
8. Clean exterior surface of engine. Spread a light film of
oil over any exposed metal surfaces of engine that are
subject to corrosion.
9. Clean dirt and chaff from radiator fins and muffler.
10. Check oil filler cap and fuel tank cap to make certain
they are securely in place.
11. Refer to engine manual for more information.
New season preparation
Before starting the tractor following post season storage,
the following servicing is required:
1. Clean tractor, removing trash and dirt accumulation.
2. Check engine oil level and common sump (for the
hydraulic lift, transmission, front axle and power
steering) and the rear axle.
3. Install a fully charged battery.
4. Check the cooling system for proper level of 50/50
solution of anti-freeze and clear water.
5. Tighten any bolts that have loosened and make sure all
hair pins, cotter pins and clevis pins are in place.
6. Install all safety shields and review safety precautions
listed in this manual.
7. Check and inflate tires to 14-18 psi (96-124 KPA).
8. Refer to engine manual for more information.
9. Start the engine and allow it to idle a few minutes. Be
sure the engine has proper oil pressure and that each
control is functioning properly.
10. Drive the unit without load and check to be sure it is
operating satisfactorily.
PRODUCT LITERATURE
If you would like to view or print a copy of the Hustler 3500/3700 product manuals go online to www.hustlerturf.com and
click on the MANUALS button.
