5
FIGURE 6
9. Assemble the boom bars to the boom mount bracket
using two 5/16" x 1-1/4" carriage bolts, tooth lock washers
(between the bar and bracket), 5/16" at washers and
knobs. The boom connecting hose should extend upward.
See gure 5.
NOTE: Make sure the nozzles are adjusted so that the
openings face straight down when the boom bar is in the
horizontal operating position.
FIGURE 5
10. Assemble the large and small spray gun clips to the
side of the tank using two #10 x 3/8" screws and #10
lock washers. See gure 6.
FIGURE 7
CARRIAGE BOLT
5/16" x 1-1/4"
KNOB
5/16" FLAT
WASHER
WASHER
(TOOTH LOCK)
BOOM BAR
BOOM CONNECTING HOSE
SPRAY GUN
CLIP (LARGE)
SPRAY GUN
CLIP (SMALL)
#10 x 3/8"
SCREW
#10 LOCK
WASHER
BOOM CONNECTING HOSE
SPRAY
GUN
HOSE
PRESSURE
GAUGE
BYPASS/RETURN HOSE
GARDEN
HOSE
GASKET
COILED
HOSE
CLAMP
11. Insert a garden hose gasket into the swivel nut on the
bypass/return hose. Screw nut onto upper outlet of the
"Y" valve tting. Place the other end of the hose down
through the hole at the rear of the tank. See gure 7.
12. Insert a garden hose gasket into the swivel nut on the
boom connecting hose. Screw the nut onto the lower
outlet of the "Y" valve tting. See gure 7.
13. Slide coiled hose clamp onto spray gun hose. Push
hose onto hose adapter on the side of the "T" tting
as shown in gure 7. Tighten clamp around hose and
adapter. Snap spray gun into clips on side of tank.
14. Carefully screw the pressure gauge into the top of the
"T" tting. See gure 7.
15. Attach sprayer to tractor hitch and connect the wiring to
tractor battery. Red wire must be connected to positive
post on battery or to "HOT" connection on a tractor switch
or ammeter. Brown wire may be grounded or connected
to negative battery post. See gures 8 and 9.
IMPORTANT: This sprayer should be connected to 12
volt batteries only!
NEVER ALLOW NEGATIVE PIN ON PLUG
TO COME IN CONTACT WITH POSITIVE
"HOT" POST ON BATTERY. FIRE OR
EXPLOSION MAY RESULT!
FIGURE 9
FIGURE 8
PLUG
NEGATIVE PIN
12 VOLT TRACTOR BATTERY
POSITIVE
"HOT"
POST
+
NEGATIVE
POST
BROWN
RED
QUICK COUPLER
BATTERY
+
RED
BROWN
IN LINE SWITCH
